Archive for November 2011

Keeping Your Asheville Air Fresh When Driving With A Clean Cabin Air Filter

What is a cabin air filter? Is it:

A. A filter for your Asheville house?
B. A fresh, piney scent?
C. A filter for the passenger compartment of your car?

Clever you, it’s C.

A cabin air filter cleans the outside air before it comes into the passenger compartment. It filters out common Asheville air particles like dust, pollen, spores, bacteria, pollutants, exhaust gas, odors and even sparrows.

These high tech filters can block particles larger than 3 microns. By contrast, a grain of sand is about 200 microns.

Not all vehicles in Asheville have cabin air filters. They are fairly new on the scene. About forty percent of new vehicles sold in Asheville come with cabin air filters, but the number is growing every year.

Cabin air filters can make for a very nice driving environment. Your car can be a haven during our Asheville allergy season with very little dust and pollen getting into the cabin. However, the filter eventually gets clogged. When this happens, your heating and air conditioning flow can become restricted. The filter can even get kind of smelly.

Check your owner’s manual for recommended replacement intervals. Often, the owner’s manual forgets about the cabin air filter, so ask your service technician at The Organic Mechanic for a recommendation. It’s usually every year or 12,000 miles / 19,000 kilometers. Change it sooner if you drive in dusty conditions around the Hendersonville area, or if you start to notice an odor from your ventilation system.

So keep your cabin air filter clean. It may not help with your brother-in-law in the backseat, but it will make your driving experience around Asheville more enjoyable.

Come by The Organic Mechanic and we'll take a look at your cabin air filter for you.

The Organic Mechanic On Your Serpentine Belt

Today we’re going to be talking about serpentine belts for our Asheville North Carolina customers. Let’s start by talking about the accessories that are driven by the serpentine belt. First is the alternator. That’s the device that makes electricity to power the vehicle and recharge the battery. Then there’s the air conditioning compressor that makes cool air for you while you're driving around Asheville North Carolina in the summer.

The power steering and power brake pumps are driven by the serpentine belt in most vehicles. Those pumps make the pressure that assists your steering and braking.

In many vehicles, the water pump is driven by the serpentine belt. The water pump is what circulates the coolant that protects your engine. In some cars around Asheville North Carolina, the water pump is driven by the timing belt.

The radiator cooling fans on some vehicles are also driven by the serpentine belt. Some have separate electric motors. That’s really a lot of work for one belt.

But modern engine design has a single belt that snakes around the front of the engine and drives most if not all of these accessories. Serpentine belts do a lot of work, but they’re tough and can last for thousands of miles.

Just how long will they last? That’ll vary for each individual car in the Asheville North Carolina area. Your manufacturer will have a recommendation for when it should be changed, but it could need it sooner. The good news is that a visual inspection can reveal a belt that’s getting close to failing.

The Organic Mechanic can look at the belt: if it has more than three or four cracks per inch it needs to be replaced. A deep crack that’s more than half the depth of the belt - replace. Frayed, missing pieces, a shiny glazed look? It’s out of there.

What’s involved in replacing the belt? First the old belt is removed. Then a new one is fitted around all the pulleys for the accessories and the drive. There’s a special pulley called a tensioner.

This pulley is mounted to the engine block with a spring loaded arm. Its job is to apply the correct amount of tension to the belt to keep it from getting loose and maybe slipping off. Because the spring in the tensioner pulley wears out, AutoNetTV recommends replacing them at the same time as the belt. It just makes sense.

What are the warning signs that there’s a problem with the serpentine belt? You may hear a squealing sound from under the hood when accelerating around our Asheville North Carolina streets. A loose belt might give you a slow, slapping sound.

What do you do if your belt breaks? If you’ve actually had that happen on our local Asheville North Carolina freeway, it can be a little scary. Often the first thing you notice is that you have no power steering or power brakes. Don’t panic – you can still steer and brake, but you’ll have to do the work. It’ll be harder to steer and you’ll need more time and effort to stop, so plan accordingly.

Your dashboard will light up will all kinds of warnings. You’ll see a warning about your cooling system if you have a water pump that’s driven by the serpentine belt. This is very critical because without your cooling system working, your engine will overheat. If you don’t stop you’ll have massive engine damage, maybe to the point that you need a new engine. Pull over as quickly as you safely can. Open your windows and turn the heater on full blast to provide a little engine cooling and pulled over as soon as possible.

The battery light will come on because the alternator isn’t working. If your car’s water pump isn’t driven by the serpentine belt, you’re not in danger of overheating so you can drive a little further if necessary. But the battery will run down to the point where the car won’t run and will just shut off. You don’t want that to happen while you’re driving in our local Asheville North Carolina traffic.

Remember, this does not have to happen if you replace your serpentine belt on schedule. Ask your technician at The Organic Mechanic to check your belts and hoses from time to time so you can take care of them if they need to be replaced prematurely.

The Organic Mechanic
568 Haywood Rd
Asheville, North Carolina 28806
828-255-2628

Charge It In Asheville For Extended Battery Life

Here's an interesting statistic for our friends in Asheville North Carolina: Only thirty percent of car batteries make it to forty-eight months. And the life expectancy varies by where you live. It ranges from fifty-one months in extremely cold areas to just thirty months in extremely hot climates.

Why is that? It turns out that it's our modern cars with all their electric accessories that are to blame. Things like, GPS, DVDs, and entertainment computers are keeping car batteries from maintaining a full charge. The longer a battery goes with a low charge, the sooner it'll die.

So you must recharge your battery. This is the job of the alternator. The problem comes when the car's demand for electricity is high and we are driving in stop and go conditions or short trips around Asheville or Weaverville. The alternator just can't keep up.

The result is shortened battery life. So what can we do to improve our battery's health?

We need to keep the battery as close to a full charge as possible. That can be hard because sitting for just twenty-four hours in hot weather between charges can be too long. When the weather's cold, sitting for several days will cause discharge.

So some highway driving between Biltmore or Arden/Fletcher will help keep a full charge if the battery has not been deeply depleted. Car batteries are not designed to be run down really low, or deep cycled, as it's called. So using your headlights or other power accessories when the car is off can deeply deplete your battery. Using the alternator to recharge from a deeply depleted state is very hard on your battery because it charges too fast. In fact, on average, your battery would only last for ten recharges like that.

If you do find yourself with a dead battery or very low battery, use a good quality battery charger to slowly bring the battery up to full charge. Follow the instructions on the charger.

Because our batteries are so often at less than a full charge, experts suggest that we use a battery charger from time to time to keep the charge up. They recommend once a month during hot weather and once every three months during colder times.

Now, a word on safety. Batteries contain sulfuric acid that can severely burn your skin and could blind you. If you find yourself with a dead battery, carefully inspect it before you jump start it. If the case is bulging, cracked or leaking, do not jump start it. Damaged batteries can explode or catch fire.

Deeply discharged batteries can freeze. Do not jump start a frozen battery.

Ask us about factory maintenance, too.

Maintenance Free Myth

Sometimes we hear people say, "What's up with all this maintenance stuff? Modern cars just don't break down." While it is true that today's cars and trucks are extremely reliable, they are also becoming increasingly complicated and use more exotic materials than ever before. All that complexity demands higher tolerances for everything. For example, most folks don't realize how high tech automotive fluids have become. Fluids like, engine oil, transmission fluid, coolant and brake fluid.

Did you know that a modern engine would not run for more than a few months using motor oil formulas from 30 years ago? Today's automotive fluids contain a much higher percentage of additives to protect your vehicle's components from premature wear and corrosion. Time and miles march on for all of our cars. Please don't think we're using scare tactics to get you to take care of your maintenance - but here are some personal stories from AutoNetTV staff members to emphasize the importance of getting things done when they are due. Names are withheld to avoid embarrassment to those who should know better. Even though they should know better, it usually comes down to real life: time and budget. But they are tales of a stitch in time saves nine.

The first comes from a staffer who bought a used pick-up truck for his son. The oil was clean and all the fluids were topped off. A short time later, the truck overheated on the highway and shut down. The repair shop diagnosed the problem: the radiator pan was corroded and dumped the coolant. Even though the coolant level was correct, it was clear that the coolant had never been exchanged - just topped off from time to time. While this kept the engine cool, all of the anti-corrosion additives had worn out; the coolant became acidic and ate through the radiator pan. The cost: hundred of dollars and four days in the shop. This demonstrates the need to get your coolant exchanged on schedule.

Another story involves the true cost of skipping an annual inspection. Our staffer took his SUV in for the North Carolina safety inspection to renew his registration. At the inspection station, he learned that the law had changed and that his newer rig only required an inspection every two years. He was very happy to save the $45 bucks. The problem was, his rear brake pads were very worn. Two months later, it was bad enough that he could hear the grind - over the radio, DVD player and the kids. He took it in to get the bad news. Both of the rear brake rotors were damaged. The left one could be resurfaced. The right had to be replaced. So saving a few bucks on his safety inspection turned into an extra $500 over what brake pad replacement would have been. Moral of the story: don't skip your annual inspections. The irony is that many Asheville service centers would have done a brake inspection for free.

Next: a teenage daughter and a curb. Daddy's little princess smacked a curb when she turned into a shopping center and popped the tire. The problem came when Dad didn't get an alignment. The impact was hard enough to ruin the tire - so it was hard enough wreck the alignment. But instead of an alignment after the first tire, Papa ended up buying a second tire a few months later - and then an alignment.

Situation: son and wife with cars from the same manufacturer with essentially the same engine. Our staffer checked the son's maintenance schedule and saw that it needed a timing belt replacement at 90,000 miles/145,000 km. He had it done - it cost several hundred dollars. His wife's car had about 60,000 miles/97,000 km, so it should be ok for a while. Right? Wrong. The problem was that the wife had the turbo charged version. Its belt was scheduled for replacement at 60,000 mi/97,000 km. At 63,000 mi./101,000 km, the belt snapped on the interstate. The valves all crashed down into the cylinders at high speed and the entire head was shredded and had to be replaced. The cost: several thousand dollars. Does he wish he had checked the maintenance schedule? You bet he does - every time he passes a big-screen TV.

We're talking about taking care of little things before they become big things. And when you take care of the little things, your car runs better and is more economical to operate. Remember to save those maintenance records. It'll show potential buyers that you've taken care of your vehicle and it will help you get a better price. Or when you buy a used car, check those records. If there aren't any, assume that the maintenance hasn't been done and take it to your Weaverville or Arden/Fletcher service center for an inspection. Take care of unperformed maintenance sooner rather than later.

Fuel Saving Tip: Dirty Oil In Your Asheville car

If you're a quart low in your car, there isn't enough motor oil to lubricate your engine properly. The extra friction causes drag that reduces fuel economy while you're driving around the Hendersonville area.

The same goes for dirty oil; it doesn't reduce friction properly. The result is you get to watch those numbers at your local Hendersonville gas pump rolling higher and higher.

The transmission also needs the proper amount of clean fluid to do its work. When it's in need of service, the transmission drags your fuel economy down.

So keep it clean and give yourself a fighting chance.

The Organic Mechanic
568 Haywood Rd
Asheville, North Carolina 28806
828-255-2628

Search

Archive

Categories